MATERIAL SAFETY DATA SHEET
This MSDS complies with OSHA'S Hazard Communication Standard 29 CFR 1910.1200 and OSHA Form 174
IDENTITY AND MANUFACTURER'S INFORMATION |
||||||||
NFPA Rating: Health-2; Flammability-0; Reactivity-1; Special- - |
HMIS Rating: Health-3; Flammability-0; Reactivity-1 Personal Protection-C |
|||||||
Manufacturer's Name: K-CHEM, INC. Address: P.O.Box 530632 Birmingham, AL 35253 |
DOT Hazard Classification: Corrosive Material, 8 Identity (trade name as used on label): K-CHEM EXCEL |
|||||||
Date Prepared: 01/15/02 Prepared By: HB |
MSDS Number: DG48B Revision - 3 |
|||||||
Information Calls: (205) 592-0844 EMERGENCY RESPONSE NUMBER: 1(800) 255-3924 |
NOTICE: JUDGMENT BASED ON INDIRECT TEST DATA |
|||||||
SECTION 1 - MATERIAL IDENTIFICATION AND INFORMATION |
||||||||
COMPONENTS-CHEMICAL NAMES AND COMMON NAMES (Hazardous Components 1% or greater; Carcinogens 0.1% or greater) |
CAS Number |
SARA III LIST |
OSHA PEL (ppm) |
ACGIH TLV (ppm) |
Carcinogen Ref. Source ** |
|||
SODIUM HYDROXIDE |
1310-73-2 |
No |
2mg/m3 |
2mg/m3 |
d |
|||
|
|
|
TWA ceiling |
TWA ceiling |
|
|||
|
|
|
|
|
|
|||
SECTION 2 - PHYSICAL/CHEMICAL CHARACTERISTICS |
||||||||
Boiling Point: 212ºF |
Specific Gravity (H2O=1): 1.092+/-.005 |
|||||||
Vapor Pressure: 28 MM |
Vapor Pressure (Non-Aerosols)(mm Hg and Temperature): N/D |
|||||||
Vapor Density (Air = 1): N/D |
Evaporation Rate ( water = 1): <1 |
|||||||
Solubility in Water: Infinite |
Water Reactive: No |
|||||||
Percent Volatile: 86% |
pH: 11.7+/-.05 |
|||||||
Appearance and Odor: Clear, green liquid technical odor. |
||||||||
SECTION 3 - FIRE AND EXPLOSION HAZARD DATA |
||||||||
FLAMMABILITY as per USA FLAME PROJECTION TEST (aerosols) N/A |
Auto Ignition Temperature N/A |
Flammability Limits in Air by % in Volume: % LEL: N/A % UEL: N/A |
||||||
FLASH POINT AND METHOD USED (non-aerosols): No flash @ boil (c.c) SPECIAL FIRE FIGHTING PROCEDURES: None. |
EXTINGUISHER MEDIA: All type as determined by primary cause of combustion. |
|||||||
Unusual Fire & Explosion Hazards: None. |
||||||||
SECTION 4 - REACTIVITY HAZARD DATA |
||||||||
STABILITY [ X ] STABLE [ ] UNSTABLE |
HAZARDOUS POLYMERIZATION [ ] WILL [ X ] WILL NOT OCCUR |
|||||||
Incompatibility: None. |
Conditions to Avoid: None. |
|||||||
Hazardous Decomposition Products: None. |
||||||||
SECTION 5 - HEALTH HAZARD DATA |
||||||||
PRIMARY ROUTES OF ENTRY: [ X ] INHALATION [ X ] INGESTION [ X ] SKIN ABSORPTION [ X ] EYE [ ] NOT HAZARDOUS |
||||||||
ACUTE EFFECTS: Contains corrosive material which causes burns. |
||||||||
Inhalation: May cause irritation, nausea, headache, dizziness, pain, decreased breathing capacity, internal bleding, chemical pneumonia, depending on severity of exposure. |
||||||||
Eye Contact: May cause severe burns that result in damage & even blindness. |
Skin Contact: May cause burns, tissue destruction, skin damage. Effects may be delayed. |
|||||||
Ingestion: Can cause severe irritation, burns, tissue ulceration, gastrointestinal damage, even death. |
||||||||
CHRONIC EFFECTS: Tissue damage depending on location and degree of exposure. |
||||||||
Medical Conditions Generally Aggravated by Exposure: Dermatitis. |
||||||||
EMERGENCY FIRST AID PROCEDURES |
||||||||
Eye Contact: Immediately flush with large amounts of water for 15 minutes while holding lids apart, then seek medical attention. |
||||||||
Skin Contact: Immediately remove contaminated clothing & footwear & wash contaminated areas with plenty of water for 15 minutes. If tissue damaged, seek medical attention. |
||||||||
Inhalation: If person experiences nause, headache or dizziness, move to fresh air until symptoms disappear. If breath is difficult, administer oxygen, keep person warm and at rest. Call a physician. Ensure adequate ventilation and provide respiratory protection before person returns to work. |
||||||||
Ingestion: DO NOT INDUCE VOMITING. Immediately drink large quantities of water. Get immediate medical attention. Never give anything by mouth if the person is unconscious or having convulsions. |
||||||||
SECTION 6 - CONTROL AND PROTECTIVE MEASURES |
||||||||
Respiratory Protection (specify type): NIOSH/MSHA respirator approved for your conditions of exposue. For emergencies, a NIOSH/MSHA approved positive pressure breathing apparatus should be readily available. |
||||||||
Protective Gloves: Chemical resistant clothing, impervious gloves, rubber apron, rubber boots. |
Eye Protection: Chemical goggles, faceshield. Always wear eye protection when working with chemicals. Do not wear contact lenses when working with chemicals. |
|||||||
Ventilation Requirements: Normal room ventilation is generally adequate. Use adequate local exhaust ventilation where mist or spray may be generated. |
||||||||
Other Protective Clothing & Equipment: Clothing as needed to minimize contact. |
||||||||
Hygienic Work Practices: Do not eat, drink or smoke in work area. Wash immediately on contact. |
||||||||
SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE |
||||||||
Small Spills: Wipe up product, rinse soiled area with water down drain. Large Spills: Stop leak at the source and collect into a suitable container, then treat as a small spill. |
||||||||
Waste Disposal Methods: Dispose of in accordance with all local, state and federal regulations. |
||||||||
Precautions To Be Taken In Handling & Storage: Store in original shipping containers. Keep closed when not in use. Shelf life 1 year. Protect from extreme heat and cold. Avoid bodily contact. |
||||||||
Other Precautions &/or Special Hazards: KEEP OUT OF REACH OF CHILDREN. Always store unused portion in original container with lid closed securely. Avoid temperature extremes. Read & follow label directions. |
We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind.
** Chemical Listed as Carcinogen or Potential Carcinogen. [a] NTP [b] IARC Monograph [c] OSHA [d] Not Listed [e] Animal Data Only